DE600S GC (60 Hz) Generator Set

DE600S GC (60 Hz) Generator Set

Caterpillar is leading the power generation marketplace with Power Solutions engineered to deliver unmatched flexibility, expandability, reliability, and cost-effectiveness.

Generator Set Specifications
Minimum Rating
600 ekW
Maximum Rating
600 ekW
Emissions/Fuel Strategy
Non Regulated
Voltage
220 to 480 Volts
Frequency
60 Hz
Speed
1800 RPM
Duty Cycle
Standby
Engine Specifications
Engine Model
C15 In-line 6, 4-cycle diesel
Bore
5.4in
Stroke
6.8in
Displacement
928in³
Compression Ratio
16.1:1
Aspiration
Turbocharged Air-to-Air Aftercooled
Fuel System
EUI
Governor Type
Adem™A4
Generator Set Dimensions
Length - Maximum
131in
Width - Maximum
60.6in
Height - Maximum
86.1in
Dry Weight - Genset (maximum)
8364lb

Standard Equipment:

Engine
  • Cat® C15 Inline 6 Cylinder, 4 Stroke Diesel
 
Air Inlet
  • Air Cleaner
 
Control Panels
  • GCCP 1.1
 
Governor
  • Mechanical Governor
 
Cooling
  • Package mounted radiator
 
Alternator
  • A Frame Standard Alternator
 
Control Panel
  • EMCP 4 Genset Controller
 
Fuel Storage
  • Single Wall 8 Hour Tank
 
Cooling System
  • Radiator and cooling fan with guards
  • Fan drive, battery charging alternator drive
 
Fuel
  • Fuel priming pump
  • Primary fuel filter with integral water separator
  • Secondary fuel filter
 
Exhaust
  • Exhaust flange outlet
 
Electrical Options
  • 3 Pole Circuit Breaker
  • Neutral Earth Link
  • 24 Volt battery with rack and cables
 
Air Inlet System
  • Air cleaner; light duty with disposable element
 
Lube System
  • Lubricating oil
  • Oil drain line with valve
 
Generator
  • Matched to the performance and output characteristics of Cat engines
  • IP23 Protection
  • Load adjustment module provides engine relief upon load impact and improves load acceptance and recovery time
 
Mounting System
  • Captive linear vibration isolators
  • Lifting provision and drag points
 
General
  • Engine and alternator pre paint, Caterpillar yellow
  • Engine and alternator pre paint, Caterpillar yellow
  • Paint - Caterpillar Yellow except rails and radiators gloss black
 
Power Termination
  • Bus Bar
 
Generator And Attachments
  • Power center, IP22
  • Optional LC frame generator - IP23 Protection
  • Mandatory Option circuit breaker, IEC, 3 pole, mounted in power centre
  • Integrated Voltage Regulator
  • Segregated low voltage (AC/DC) wiring panel
 
Mounting
  • Rubber vibration isolators
 
Governing System
  • Cat Electronic Governor (ADEM A4).
 
Lube System
  • Oil drain valves
  • Oil cooler
 
Mounting System
  • Captive linear vibration isolators between base and engine-generator includes lifting provisions and termination points for coolant and lube oil drain lines
 
Starting/charging
  • 24 volt starting motor
  • Batteries
  • 24 Volt battery with rack and cables
 

Optional Equipment:

Exhaust
  • Industrial, Residential, Critical Mufflers
 
Control Panel
  • Speed and Voltage Adjust Potentiometers
  • PLG 4G/3G/Ethernet
  • Annunciator
  • Emergency E-Stop
 
Enclosure
  • Cat GC Enclosure
 
Generator
  • Oversize and premium generators
  • Anti-condensation heater
  • Excitation: [ ] Permanent Magnet Excited (PM) [ ] Internally Excited (IE)
 
Power Termination
  • Circuit breakers, UL listed
  • Circuit breakers, IEC compliant
 
Electrical Options
  • 4 Pole circuit breaker
  • Auxiliary Contacts
  • Pad-lockable circuit breaker
  • Battery Charger
  • Wet Battery
 
Alternator
  • Space Heater
  • AVR
 
Fuel System
  • Dual Wall 8Hr Fuel Tank
  • Single Wall 8Hr Fuel Tank with Spill Containment
  • Low Fuel Level Shutdown
  • Low and High Fuel Level Alarms
  • Manual fuel transfer pump
  • Fuel transfer system controls
  • Dual wall fuel tank base
 
Starting/charging
  • Jacket water heater
  • Heavy-duty starting system
  • Battery chargers
  • Charging alternator
  • Oversize batteries
 
Air Inlet System
  • Single Stage Air Filter
  • Dual Element Air Filter
 
Certifications
  • EU certificate of conformance
  • EAC certification
 
Extended Service Coverage
  • 3, 4, 5 and 10 Years
 
General
  • The following options are based on regional and product configuration:
  • Single or dual wall integral fuel tanks
  • Narrow, Wide or Skid Base
  • Seismic Certification per applicable building codes: IBC 2000, IBC 2003, IBC 2006, IBC 2009, CBC 2007
  • EU Certificate of Conformance (CE)
  • CSA Certification
  • EEC Declaration of Conformity
  • Integral & sub-base UL listed dual wall fuel tanks
  • UL 2200 package
  • Sound attenuated, weather protective or high ambient weather protective enclosure
  • Automatic transfer switches (ATS)
  • Single or dual wall sub-base fuel tanks
 
Enclosures
  • High ambient sound attenuated enclosures
 
Exhaust System
  • Industrial Silencer
  • 10 dBA Attenuation silencer
  • Flexible exhaust fittings
  • 6 and 8 inch elbow kit
  • End in / End out mufflers - 10, 25 and 35 dBA attenuation
  • Engine mounted muffler
  • Manifold and turbocharger guard
  • 6 and 8 inch flange GP
 
Generator And Attachments
  • Oversize A frame generator
  • Permanent magnet generator
  • Oversize LC frame generator
  • Ingress protection
  • LC frame generator
  • Space heaters
  • LC frame CIP generator
  • CIP a frame generator
 
Lube System
  • Manual sump pump
 
Mounting System
  • Narrow skid base - replaces standard fuel tank base
 
Special Test / Reports
  • PGS Test report @ 1.0 power factor
  • PGS Test report @ 0.8 power factor
 
Starting / Charging System
  • 5 Amp single battery charger
  • Battery disconnect switch
  • Jacket water heater
 

    This site is protected by reCAPTCHA and the Google Privacy Policy and Terms of Service apply.

    Share This Product